概述：混凝土搅拌机发生故障时时候，若没有及时将搅拌罐内的清理出来，时间一久将会凝固，会给我们带来很大的经济损失。那么你知道在紧急情况下如
混凝土搅拌机发生故障时时候，若没有及时将搅拌罐内的清理出来，时间一久将会凝固，会给我们带来很大的经济损失。那么你知道在紧急情况下如何清理混凝土搅拌机内的混凝土吗？
When the concrete mixer breaks down, if the mixing tank is not cleaned in time, it will solidify after a long time, which will bring us great economic losses. Do you know how to clean the concrete in the concrete mixer in an emergency?
方法一：
Method 1:
1、准备好紧急驱动软管，将故障混凝土搅拌机熄火，卸下液压马达上的高压油管接头。
1. Prepare the emergency drive hose, turn off the faulty concrete mixer, and remove the high-pressure oil pipe connector on the hydraulic motor.
2、将救援車熄火，将其液压马达的高压油管卸下，并与故障車上的对应接头用紧急驱动软管相连。
2. Turn off the rescue truck, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the faulty truck with the emergency drive hose.
3、发动救援車，将其操纵手柄拨出料位置，故障車内的商品混凝土即被排出。
3. Start the rescue truck and turn its operating handle to the discharge position, and the commercial concrete in the faulty truck will be discharged.
4、紧急驱动完毕后，将驱动软管卸下，并恢复两車原状。
4. After the emergency drive is completed, remove the drive hose and restore the two vehicles to their original state.
方法二：
Method 2:
1、若个方法实行有困难，则采用以下方法，立即排出商品混凝土。
1. If the above methods are difficult to implement, the following methods shall be adopted to discharge the commercial concrete immediately.
2、在托轮和滚道之间放入木楔，以控制搅拌筒的旋转，一定要注意；将发动机熄火，拆松液压马达的一根高压油管，搅拌筒可自由旋转，控制搅拌筒的旋转，使维修孔转到下部，然后打开维修孔，清理出筒内商品混凝土。
2. Put a wooden wedge between the supporting wheel and the raceway to control the rotation of the mixing drum. Be careful; Turn off the engine, dismantle a high-pressure oil pipe of the hydraulic motor, the mixing cylinder can rotate freely, control the rotation of the mixing cylinder, make the maintenance hole turn to the lower part, then open the maintenance hole, and clean out the commercial concrete in the cylinder.
此时一定要注意，商品混凝土排出完毕后，恢复混凝土搅拌机原状。紧急清理混凝土搅拌机内商品混凝土是我们每个混凝土搅拌机司机都应该会的，在混凝土搅拌机发生故障的时候，及时清理，将损失降到低。
At this time, it must be noted that after the commercial concrete is discharged, the concrete mixer shall be restored to its original state. Emergency cleaning of commercial concrete in the concrete mixer is what every concrete mixer driver should know. When the concrete mixer breaks down, it should be cleaned in time to reduce the loss.
混凝土搅拌机的混凝土凝固怎么办？以上给您讲解了两个方法，您可以作為参考，根据自己的实际情况来尝试下，当然要做好充分的提前了解，行事。更多相关内容就来我们网站
http://www.zkhntjbj.com咨询！
What about the concrete solidification of the concrete mixer? The above two methods have been explained to you. You can try them according to your actual situation as a reference. Of course, you should fully understand in advance and act safely. More relevant content will come to our website http://www.zkhntjbj.com consulting service
全國服務热線
点击拨打服務热線：400-879-1999
